Chevrolet Malibu owners have reported 17problems related to suspension noise (under the suspension category).The most recently reported issues are listed below.Also please check out thestatistics and reliability analysis of Chevrolet Malibu based on all problems reported for the Malibu.
1 Suspension Noise problem of the 2016 Chevrolet Malibu
Failure Date: 05/11/2021
My car won't shift into park sometimes and the suspension is making a poppin noise and my cruise control is not working.
See all problems of the 2016 Chevrolet Malibu🔎.
2 Suspension Noise problem of the 2017 Chevrolet Malibu
Failure Date: 10/03/2020
Rear control arm bushings have worn out after only 40,000 miles causing a popping noise in the rear suspension. I was told this would need replaced every 30,000 to 40,000 miles to prevent damage to the control arm. Popping could be heard the most when first taking off in either reverse or drive.
See all problems of the 2017 Chevrolet Malibu🔎.
3 Suspension Noise problem of the 2016 Chevrolet Malibu
Failure Date: 06/10/2020
The contact owns a 2016 Chevrolet Malibu. The contact stated that while driving or pulling off from a stop, there was a knocking sound coming from underneath the rear of the vehicle. The vehicle was taken to ourisman Chevrolet of bowie (16610 governor bridge rd, bowie, MD 20716), and was diagnosed that the rear suspension knuckles needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was approximately 96,990.
4 Suspension Noise problem of the 2016 Chevrolet Malibu
Failure Date: 01/01/2020
There are several hundred complaints online about a thumping noise coming from rear of 2016-2018 chevy Malibu of all trim types, particularly at low speeds or when one side of rear of vehicle goes over small bumps. Gm put out a service bulletin recommending that dealerships and service technicians add a washer to top of both rear shocks and possibly replace rear suspension knuckles. Many dealerships give customers �the runaround�, requiring them to pay for diagnostic fees and repairs, performing other repairs and replacements that do no fix the problem, and telling customers to just deal with it. This rear knuckle part is on a national back order, causing delays of approximately 6 months for the safe and timely repair of this issue. Without these washers on the rear shocks, the top of the shock makes physical contact with the bottom of the strut mount, causing the suspension knuckle to fail, which then causes bushings to fail. This is a very serious safety hazard that Chevrolet is largely ignoring.
5 Suspension Noise problem of the 2016 Chevrolet Malibu
Failure Date: 09/03/2019
The rear suspension of our car started making a metallic popping noise when we drove over bumps or accelerated from a traffic light. The sound also occurred when someone sat in the rear seat with the car parked. Integrity Chevrolet of chattanooga, TN determined that both knuckles in the rear suspension needed to be replaced. The service writer told me that if this had been left unaddressed, it could cause a safety issue as there was metal rubbing against metal.
6 Suspension Noise problem of the 2008 Chevrolet Malibu
Failure Date: 01/10/2014
Front suspension started to make a lot of noise. Front pro-steer sway bar & f stabilizer was identified causing the problem. Also defaulted part is the control arm w/ball joint.
See all problems of the 2008 Chevrolet Malibu🔎.
7 Suspension Noise problem of the 2010 Chevrolet Malibu
Failure Date: 03/22/2012
Upon accelerating from a parking lot to the road I heard a loud bang from the rear of the car. I stopped to do a visual inspection as it sounded like it came from the rear suspension. I continued a mile down the road while slowing for a stop sign I heard another noise from the same area and heard a metal object bounce under the car and down the road. I recovered a piece of a broken spring that had come from my right rear suspension. I went directly to the chevy dealer and they confirmed the failure.
See all problems of the 2010 Chevrolet Malibu🔎.
8 Suspension Noise problem of the 2003 Chevrolet Malibu
Failure Date: 03/05/2012
I am currently experiencing loss of steering and suspension performance with my vehicle including significant loss of tire tread for my vehicle. The vehicle bounces and makes screeching sounds while steering a curve on the road. The vehicle was inspected in early March and no mechanical problem was observed or detected. A 4 wheel alignment was also done at a Chevrolet dealer a few months back and no problems were found or detected then. I have reason to believe that something is wrong with the mechanical operation of either the steering or suspension component of the vehicle. Kindly investigate and look into this problem. Thank you.
See all problems of the 2003 Chevrolet Malibu🔎.
9 Suspension Noise problem of the 2006 Chevrolet Malibu
Failure Date: 02/06/2012
I have been repetitively turned away by various gm dealerships to address serious issues with my vehicle & potential recalls. My issues include - steering malfunctions making the vehicle difficult to control, faulty fuel pump sending unit causing check engine light to illuminate & vehicle to stall, uncontrollable vibrations when breaking at high speeds nearly causing me to wreck, popping sounds in the suspension system, and finally unexplained electrical malfunctions such as radio switching channels on its own, failure of keyless entry system, failure of remote entry system, buzzing of lights when dimming, and flickering of headlights. I have been told by dealerships that because my vehicle is a "fleet car" that it does not qualify for any recalls. Problems began while under warranty. Steering wiring harness was replaced while under warranty. At around 65,000 miles, systems began to fail despite my regular care of the vehicle which I have documented. After warranty expired, I was routinely turned down for recall inspections. A recent emissions inspection caused concern by the mechanic over the steering of the vehicle and I was encouraged to address these problems again. I cannot afford a new car.
See all problems of the 2006 Chevrolet Malibu🔎.
10 Suspension Noise problem of the 2009 Chevrolet Malibu
Failure Date: 12/10/2009
Purchased this vehicle brand new from dealer in June of 2009. 1st time I heard clunking noise from front suspension only when the temps drop below 50 degrees. Once car warmed up, the noise would go away. Sounded like a broken stabilizer link. Returned car to dealer and had to leave overnight so they can hear the noise, only problem was that the dealer could hear the noise when cold, but sound noise would be gone by the time they got the car on the lift. Once the sound was gone they had no clue as to where the noise started from. Returned to the dealer roughly 7 times over 3 year period, now the warranty is over. Dealer did replace links, struts, steering rack, steering intermediate shaft and a slew of other parts which I have documented. Now I have the car for 5 years and yes the noise is still there each winter morning below 50 degrees. Once the warmer weather arrives, it never makes a sound. My understanding is that a lot of gm cars all have the same "clunking" sound in front suspension. Only thing I can think of is that the dealer parts are all defective and maybe an aftermarket part may be upgraded to help eliminate the noise. As for now, I just live with it as I feel no wobbly effects or unsafe condition.
See all problems of the 2009 Chevrolet Malibu🔎.
11 Suspension Noise problem of the 2004 Chevrolet Malibu
Failure Date: 04/11/2006
: the contact stated there is a noise in the front end while turning at low speeds. The dealership determined this is the issue addressed in the technical service bulletin, manufacturer #1716682 regarding the suspension. The bulletin stated the repair is being designed and should be available in the first quarter of 2006.
See all problems of the 2004 Chevrolet Malibu🔎.
12 Suspension Noise problem of the 2005 Chevrolet Malibu
Failure Date: 09/09/2005
The contact owns a 2005 Chevrolet Malibu. While driving approximately 40 mph, there was a pulling sensation and noise underneath the vehicle. There was also excessive vibration. There was no warning light illuminated on the instrument panel. The vehicle was taken to the dealer on three separate occasions, but the failures were not resolved. The contact stated that there has been a suspension malfunction with the vehicle since it was purchased. The failure mileage was 12,000 and current mileage was 12,330.
See all problems of the 2005 Chevrolet Malibu🔎.
13 Suspension Noise problem of the 2004 Chevrolet Malibu
Failure Date: 03/11/2005
The contact owns a 2004 Chevrolet Malibu maxx. While driving at low speeds, the vehicle makes a knocking noise in the front passenger side of the vehicle. The front suspension was replaced four times and the rack was replaced once. The vehicle has been taken to the shop fourteen times. The steering shaft has been packed with grease, which serves as a temporary repair. The dealer stated that the steering shaft will need to be greased approximately every three months. The speed was unknown. The current mileage was 25,000 and failure mileage was 15,000.
14 Suspension Noise problem of the 2003 Chevrolet Malibu
Failure Date: 04/11/2004
While driving consumer heard noises coming from the front of the vehicle. Consumer took the vehicle to the dealership for inspection, and mechanic determined that suspension malfunctioned.
15 Suspension Noise problem of the 1998 Chevrolet Malibu
Failure Date: 02/01/2002
Front and rear suspension make loud squeaky noises. The noise is consistant while driving over rough and bumpy roads. Dealer confirms that suspension is bad. Dealer was notified.
See all problems of the 1998 Chevrolet Malibu🔎.
16 Suspension Noise problem of the 1998 Chevrolet Malibu
Failure Date: 06/29/1998
Repairs to vehicle started 6-29-98 and continue to present. Dealership service dept. Can repair rear suspension per gm tech. Notes but problem noise in rear suspension reoccurs within 50-300 miles. Gm has stated that they will repair vehcile under original warranty agreement, but after 10 repairs I feel this is a defect in the vehicle and not just the parts.
17 Suspension Noise problem of the 1998 Chevrolet Malibu
Possibly due to poor suspension vehicle makes noise while driving over rough roads. Yh.
Other Common Suspension related problems of Chevrolet Malibu
| Problem Category | Number of Problems |
|---|---|
| Suspension problems | 182 |
| Front Suspension Coil Spring problems | 61 |
| Front Suspension problems | 39 |
| Suspension Noise problems | 17 |
| Front Suspension Control Arm problems | 16 |
| Front Suspension Wheel Bearing problems | 15 |
| Front Suspension Hub problems | 9 |
| Front Suspension Lower Control Arm problems | 9 |
| Front Suspension Strut problems | 7 |
| Front Suspension Lower Ball Joint problems | 6 |
